In EIA's January 2023 Petroleum Supply Monthly (PSM), which includes U.S. biofuel production data through November 2022, renewable diesel production surpassed biodiesel production for the first time since EIA began reporting renewable diesel production data in EIA's Monthly Energy Review (MER) in 2011 (Figure 1).
Renewable diesel production in November 2022 averaged 113,000 barrels per day (b/d), a 38,000 b/d (51%) increase from November 2021 and a 74,000 b/d (191%) increase from November 2020. EIA forecast renewable diesel production to continue to grow and remain higher than biodiesel production, which they forecast to decrease.
U.S. renewable diesel production surpassed biodiesel production in November 2022
Renewable diesel is chemically equivalent to petroleum diesel but is produced using fats, oils, or greases rather than petroleum. Traditional diesel trucks can consume renewable diesel on its own or blended with petroleum diesel or biodiesel. Renewable diesel can also be transported through the same pipelines as petroleum diesel. Biodiesel is produced with the same feedstocks as renewable diesel but is typically blended with petroleum diesel at concentrations of 20% or less for vehicle consumption. Biodiesel and renewable diesel are used to comply with the biomass-based diesel renewable volume obligations in the Renewable Fuel Standard (RFS) administered by the U.S. Environmental Protection Agency (EPA). They also supply 95% or more of the RFS requirement for non-cellulosic advanced biofuels.
Government programs and subsidies for lower-carbon fuels are driving growth in renewable diesel production. Renewable diesel has been increasingly used to meet California’s Low Carbon Fuel Standard (LCFS), Oregon’s Clean Fuels Program, and the RFS. It will also help meet the requirements of Washington State’s Clean Fuels Program, which launched on January 1, 2023. In addition to these government programs, biomass-based diesel tax credits, which the Inflation Reduction Act of 2022 extended through 2024, have made production of renewable diesel more economical. These programs have provided incentive to build new renewable diesel plants, including Diamond Green Diesel’s plant in Port Arthur, Texas, and several plants at sites of former petroleum refineries, such as Marathon Petroleum’s Dickinson, North Dakota refinery; Phillips 66’s Rodeo, California refinery; and HF Sinclair’s Cheyenne, Wyoming refinery.
In EIA's February Short-Term Energy Outlook (STEO), they forecast that renewable diesel production will continue growing (Figure 2) as production capacity increases. They estimate that renewable diesel production in 2022 averaged 97,000 b/d, an increase of 41,000 b/d (73%) from 2021. They forecast that renewable diesel production will average 148,000 b/d in 2023, an increase of 50,000 b/d (52%) from 2022, and 211,000 b/d in 2024, an increase of 63,000 (42%) from their forecast for 2023. Their forecast shows renewable diesel production reaching 177,000 b/d at the end of 2023 and 252,000 b/d at the end of 2024.
U.S. renewable diesel production surpassed biodiesel production in November 2022
Despite this growth, they forecast U.S. renewable diesel production to remain well below the 357,000 b/d of planned production capacity shown for 2024 in our February 2 Today in Energy article for three reasons:
- The significant ramp-up in production capacity will likely increase feedstock prices, which would make renewable diesel production less profitable and could decrease plant utilization or result in some canceled planned capacity.
- Some planned capacity may come online later than planned.
- New plants will take several months before producing at full capacity.
Because biodiesel producers compete for the same constrained feedstocks as renewable diesel producers, EIA expects U.S. biodiesel production to decrease as renewable diesel production increases (Figure 3). Biodiesel production generates fewer RIN credits per gallon than renewable diesel, and biodiesel is primarily transported by rail and truck, which are more expensive than pipeline transportation.
U.S. renewable diesel production surpassed biodiesel production in November 2022
EIA expects high feedstock prices to moderate biodiesel profits and either reduce biofuel plant utilization or push less economically efficient biodiesel plants into retiring. U.S. biodiesel production capacity has already begun to decrease, according to EIA's January 2023 Monthly Biofuels Capacity and Feedstocks Update, which includes biodiesel production capacity data through November 2022. U.S. biodiesel production capacity averaged 136,000 b/d in November 2022, which was 19,000 b/d (12%) less than in November 2021. This decrease in biodiesel production capacity is likely a result of less efficient biodiesel plants losing profitability in the high feedstock price environment. Their forecast assumes that feedstock prices will remain high or rise in the short term and that more biodiesel capacity will retire.
As renewable diesel production grows, EIA also expects growth in the production of sustainable aviation fuel (SAF) and other biofuels that they capture in their “other biofuels” production data (Figure 4). They forecast U.S. production of these other biofuels to more than double from 2022 by 2024. Much of this growth will come from the renewable naphtha and renewable propane produced as coproducts of renewable diesel production and from the SAF produced at renewable diesel plants that plan to produce both. Because renewable diesel plants can produce other biofuels, they expect increases in renewable diesel production to facilitate a portion of their forecast increase for other biofuels production.
